Concrete mixer is one of the main products of our company, and its wide application has been favored by customers. Let's take you to know how to ensure the standard operation of concrete mixer truck:

　　1.每次使用混凝土攪拌車前，要檢查空壓車的自保裝置是否可靠；還要檢查攪拌車葉片的連接螺栓是否牢固；檢查各電氣裝置是否規范可靠，各限位開關是否靈活可靠；檢查潤滑點急減速是否有足夠的潤滑油。

　　1. Before using the concrete mixer truck, check whether the self-protection device of the air compressor truck is reliable; check whether the connecting bolts of the mixer blade are firm; check whether the electrical devices are standard and reliable; whether the limit switches are flexible and reliable; check whether there is enough lubricating oil for the rapid deceleration of lubricating points.

　　2.每次使用之后，都應該將混凝土攪拌車的主車內外、料門上的積料清理并沖洗干凈；各個潤滑點應加注潤滑油，尤其是在軸端的密封處萬不可遺漏；冬季應該放盡水路內的液體，放盡空壓車貯氣筒內的積水和氣體；停車后，所有的開關都要處于非工作狀態并切斷電源。

　　2. After each use, the accumulated materials inside and outside the main truck and on the material door of the concrete mixer truck should be cleaned and washed; all lubricating points should be filled with lubricating oil, especially at the sealing part of the shaft end; in winter, the liquid in the water channel should be drained, and the water and gas in the air storage cylinder of the air compressor should be exhausted; after stopping, all switches should be in non working state and cut off Power Supply.
             

　　3.每周還要對設備盡心例行保養。保養的內容為：檢查攪拌罐內殘留砼的凝結情況，如有凝結應停車進行鏟除（注意應切斷電源專人看護），檢查攪拌葉片與襯板間隙，如不適合進行調整；檢查氣路系統是否漏氣，氣缸動作是否可靠；檢查減速箱內的潤滑油的質量和液面高度，必要時加注或更換；檢查供水系統中吸水底閥是否可靠；檢查各電器元件是否有損壞現象，必要時修理或更換，檢查各接線是否松動；擰開放淤塞，檢查軸端密封情況，無異常后再擰入放淤塞。

　　3. The equipment should be maintained every week. The maintenance contents are as follows: check the condensation of residual concrete in the mixing tank; if there is condensation, stop the machine to remove it (pay attention to cut off the power supply and take care of special personnel); check the clearance between the mixing blade and the lining plate, and adjust if it is not suitable; check whether the air passage system leaks and whether the cylinder action is reliable; check the quality and level of lubricating oil in the reducer box, and add or replace it if necessary; Check whether the suction bottom valve in the water supply system is reliable; check whether the electrical components are damaged, repair or replace if necessary, and check whether the wiring is loose; open the blockage, check the sealing condition of the shaft end, and screw in and drain the blockage after there is no abnormality.

　　4.每隔一個月，還要進行檢查保養。月例檢查的范圍包括：檢查螺旋輸送車內是否有結塊和雜物，如有則；檢查皮帶的張緊情況，并作適當?shù)恼{(diào)整；檢查葉片，襯板的磨損情況；檢查上、下車架、料倉、大斜皮帶車等部件的連接螺栓是否牢靠，地基是否下沉。

　　4. Check and maintain every other month. The scope of monthly inspection includes: check whether there are caking and sundries in the screw conveyor, and remove them if they are; check the tension of the belt and make appropriate adjustment; check the wear of the blades and lining plates; check whether the connecting bolts of the upper and lower frame, silo, large inclined belt car are firm, and whether the foundation is sinking.

　　除了這些例行檢查以外，每年還要對運行工作的混凝土攪拌車或混凝土攪拌車進行全方面的檢查，檢查中如果發現問題要及時維修，有的車器零部件若損壞要及時更換以保證設備的正常運行。

　　In addition to these routine inspections, all aspects of the running concrete mixer truck or concrete mixer truck should be inspected every year. If problems are found during the inspection, timely maintenance should be carried out. If some parts of the vehicle are damaged, they should be replaced in time to ensure the normal operation of the equipment.

　　以上是如何保證混凝土攪拌車的規范運作。相信大家對混凝土攪拌車都有了解。

　　The above is how to ensure the standard operation of concrete mixer truck. I believe that everyone has an understanding of the concrete mixer.